Team:Bielefeld-CeBiTec/Results/rMFC/ElectronTransfer

From 2014.igem.org

Revision as of 18:08, 17 October 2014 by J droste (Talk | contribs)



Module I - reverse microbial fuel cell (rMFC)

-->
Construction of an electrophilic E. coli strain

Our first module deals with the construction of an E. coli strain, which is able to accept electrons stimulating its metabolism. We considered two different electron transfer systems: direct and indirect electron transfer.
Direct electron transfer in bacteria is a very complex and not completely cleared up so far. Due to this we focused on the indirect electron transfer via a mediator, which is reduced at the electrode in a electrobiochemical reactor and would be reoxidized again by bacterial cells.(Park et al., 1999) In gram-negative bacteria E. coli there are two membranes with a periplasmatic space between them, which has to be overcome in the course of the electron transfer.
We worked on three different mediators: neutral red, bromphenol blue and cytochromes. Additionally we constructed an electropholic E. coli strain, which shows an increased metabolic activity growing with electric power, which has been proven in our H-cell reactor (Park et al., 1999).
The electron transfer system consists of different steps. First of all the reduced mediator has to cross the outer membrane of the E. coli cell. For that we used the outer membrane porine OprF (BBa_K1172507) provided by the iGEM Team Bielefeld-Germany 2013. Crossing the periplasmatic space, the mediator adsorb at the inner membrane of the E. coli cell. The mediator functions as an electron donor for the over expressed fumarate reductase. In this step succinate is produced in the cytoplasm. Reduction of fumarate into succinate creates a loop into the citric acid cycle, because succinate would be reoxidized again by the succiante dehydrogenase. Succinate excretion is avoid, because of the knockout of the C4 carboxylate transporter DcuB. In the reaction of succinate dehydrogenase electrons are transferred to FAD+ generating FADH2, which enter the electron transport chain. The electron transport facilitates proton translocation over the inner bacterial membrane. The proton motoric force is used by ATP synthase. Generated ATP and reductive power in the bacterial cell leads to an increasing metabolic activity.

E. coli KRX ΔdcuB::oprF strain

We investigated the effect of the C4 carboxylate transporter dcuB knockout on E. coli KRX. Furthermore we showed the integration of the outer membrane porine OprF (BBa_K1172507) into the bacterial genome by replacing the gene of E. coli C4 carboxylate antiporter dcuB. So we did knockout and insertion in a one-step process. The successful knockout of the dcuB antiporter and simultaneous insertion of BBa_K1172507 was shown with PCR analysis, DNA sequencing and phenotypic investigation via Biolog analysis and anaerobic cultivation in M9 minimal media with fumarate supplemented. Substrates and products were analyzed by HPLC. The electrobiochemical behavior of E. coli KRX with knocked out C4 carboxylate antiporter dcuB was tested in a H-cell reactor.

Preparation of knockout deletion cassette

We create an E. coli knockout strain with GeneBridge. We decide to knock out the C4 carboxylate transporter dcuB to prevent succinate export. Besides we inserted the outer membrane porines OprF (BBa_K1172507) into the genome. Both could be realized with the Genebridge RedET-System. For simultaneous knockout and insertion a deletion cassette had to be designed and established. We used overlap extension PCR to amplify the complete deletion cassette (Bryksin & Matsumura, 2010). We used kanamycin as an antibiotic selective marker amplified from the plasmid Flp705 using the Genebridge RedET-System protocoll. We designed the primers (BBa_K1465107, BBa_K1465108, BBa_K1465109, BBa_K1465110) with complementary 5´extensions for both fragments to connect them in overlap extension PCR. The amplified deletion cassette has homologous sites for recombination with the dcuB gene in the E. coli KRX genome.

PCR analysis

The gene of the C4 carboxylate transporter dcuB, which exchange fumarate against succinate, has a size of 1341 bp. We amplified the genome area of the dcuB gene with primers (dcuB_del_kon1 and dcuB_del_kon2), which bind 530 bp upstream and 520 bp downstream of the dcuB gene. When using the E. coli KRX wildtype as a template the resulting PCR product has a size of 2391 bp, which could be demonstrated by agarose gelelectrophoresis. However the E. coli KRX knockout strain (E.coli KRX ΔdcuB::oprF) showed a 4046 bp PCR product analyzed by agarose gelelectrophoresis. Figure XXX shows the result of the agarose gelelectrophoresis with E. coli KRX wildtype and the modified strain E.coli KRX ΔdcuB::oprF.

ABBILDUNG
The PCR product of E.coli KRX ΔdcuB::oprF genome amplified with primer dcuB_del_kon1 and dcuB_del_kon2 (4046 bp) and is composed of the antibiotic cassette (1637 bp), BBa_K1172507 (1359 bp) and upstream and downstream spacer elements (520 bp and 530 bp).

Sequencing

DNA sequencing of deletion cassette from E.coli KRX ΔdcuB::oprF showed the expected results.

NPN-Assay

The funtionality of the outer membrane porin OprF (BBa_K1172507) in E.coli KRX ΔdcuB::oprF was investigated with a NPN-Uptake-Assay (Cheng et al., 2005).
1-N-Phenylnaphthylamine (NPN) changes fluorescence activity between aqueous and hydrophobic milieus. There is only minor fluorescence in aqueous solution, but the transport in the hydrophobic periplasmatic space causes an increased fluorescence. So NPN fluorescence is a good indicator for membrane permeability. Expression of the outer membrane porines OprF effect an increasing membrane permeability.(Loh et al., 1984)


Figure XXX: Results of the NPN-Uptake-Assay. Comparison between Escherichia coli KRX wildtype and Escherichia coli KRX with BBa_K1172507, BBa_K1172502 and Escherichia coli KRX with genome integrated oprF gene (E.coli KRX ΔdcuB::oprF).
Figure XXX shows the results of the NPN-Uptake-Assay. Higher fluorescence emission and higher membrane permeability could be observed with increasing promotor strength for oprF. The genome integrated oprF shows mid-level fluorescence emission and membrane permeability. Highest fluorescence levels could be measured with the oprF gene on a high-copy pSB1C3 plasmid under control of the T7 promotor.
Genome integrated oprF showed almost the same membrane permeability as the constitutive expressed oprF with BBa_K1172507. There even seems to be a marginal higher expression of the genome integrated oprF in contrast to the plasmid coded oprF although the same constitutive promotor (BBa_J23104) is used. This could be explained by physiological condition of the cell. Constitutive expression of high-copy oprF causes cell stress. Protein expression could be automatically downregulated by the cells. Single-copy genome integrated oprF show minor expression level, therefor cell stress is also smaller. As a consequence E. coli cells show a more effective expression of outer membrane porin OprF adjusted on physiological cell condition.

Phenotypic characterization with Biolog® system

Biolog® Microbial ID System is a simple and fast method for characterization of different bactaria, yeast and fungi species. It based on respiration in the presence of different metabolic relevant substances for expample carbon sources, nitrogen sources or toxines. The system uses redox chemistry wherein a tetrazolium dye is reduced when significant respiration occurs. Tetrazolium dye change its colour, because the cells generate reductive conditions in the course of electron transport chain. Tetrazolium cation is reduced to formazan by dehydrogenase from respiratory complex I. This allow a statement if respiration occurs in the presence of different substances.

E. coli KRX Wildtype and E.coli KRX ΔdcuB::oprF were incubated in Biolog® system to test respiration in the presence of fumarate. It has to be shown that E.coli KRX ΔdcuB::oprF shows no activity in the presence of fumarate because knockout of C4 carboxylate transporter dcuB makes fumarate uptake impossible for E. coli cells.
The results of Biolog® analysis are shown in figure XXX.


Figure XXX: Results of Biolog® analysis of E.coli KRX ΔdcuB::oprF in comparison to Escherichia coli KRX wildtype. Respiratory activity is shown under influence of fumarate.

Biolog® analysis shows that there is no significant respiratory activity of E.coli KRX ΔdcuB::oprF in the presence of fumarate among the first 35 hours of incubation. Later on respiration occurs up to 50% of maximal respiratory activity of E. coli KRX wildtype after 48 hours of incubation at 37°C.
The results in figure XXX demonstrate that knockout of C4 carboxylate antiporter DcuB was successful. Respiration activity after 35 hours could be explained by a change in metabolism of E. coli cells. Based on cell stress in minimal medium bacteria use other ways for respiration in the presence of fumarate. It is possible that an other transporter compensate activity of DcuB transporter, but activation and expression of alternative pathways require a space of time. This could explain the lag of time until respiration of E.coli KRX ΔdcuB::oprF occurs.
Anaerobic cultivation

We cultivated E. coli KRX ΔdcuB::oprF under anaerobic conditions. We used M9 minimal medium with 50 mM glucose. Among growth characteristic we focused on metabolite analysis. Under anaerobic conditions E. coli cells use different alternative electron acceptors instead of oxygen. In part the bacteria use fumarate respiration, whereby fumarate is reduced into succinate. There are also other potential pathways for bacteria to release their electrons, for example anorganic compounds like nitrate (NO3-) or sulfate (SO42-).(Gottschalk et al., 1986) As a result of this the expected level of produced succinate is very low. We analyzed succinate concentration and glucose concentration in culture supernatant via HPLC.

We expect succinate production of E. coli KRX wildtype, but E. coli KRX ΔdcuB::oprF should not release succinate into the media because C4 carboxylate transporter dcuB is knocked out. As a positive control we use E. coli ΔdcuB749::kan, an E. coli strain with a reviewed knockout in dcuB gene. This strain also should not show any succinate transport into the medium.



Figure XXX: Results of anaerobic cultivation of Escherichia coli KRX wildtype in M9 minimal medium with 50 mM glucose. Glucose and succinate concentration were measured with HPLC.


Figure XXX: Results of anaerobic cultivation of Escherichia coli ΔdcuB749::kan in M9 minimal medium with 50 mM glucose. Glucose and succinate concentration were measured with HPLC.


Figure XXX: Results of anaerobic cultivation of Escherichia coli KRX ΔdcuB::oprF in M9 minimal medium with 50 mM glucose. Glucose and succinate concentration were measured with HPLC.


Figure XXX: Results of anaerobic cultivation of Escherichia coli KRX ΔdcuB::oprF in M9 minimal medium with 50 mM glucose as compared to Escherichia coli KRX wildtype. Glucose and succinate concentration were measured with HPLC.

Figure XXX shows production of succinate by Escherichia coli KRX wildtype under anaerobic condition as expected. Succinate is released into the medium via C4 carboxylate transporter DcuB. Our constructed E. coli KRX ΔdcuB::oprF strain shows no succinate export under anaerobic conditions displayed in figure XXX. This demonstrate a successful knockout of dcuB gene in E. coli KRX ΔdcuB::oprF strain. As positive control we get an E. coli strain from the KEIO collection with a verified knockout in dcuB gene. Figure XXX shows the result of anaerobic cultivation and succinate concentration measurement of this E. coli strain. A very low succinate concetration in culture supernatant could be observed. In comparison to E. coli KRX wildtype there is a very low succinate export. Only traces of succinate could be measured attributed to a residual activity of DcuB antiporter or transport of succinate by other transporters with minor specifity.
Furthermore in Escherichia coli ΔdcuB749::kan the knockout is not over the complete dcuB gene. Insertion of kanamycin selection cassette was executed at position 749 of dcuB gene. So there could be a residual activity of DcuB because of residual expressed parts of antiporter protein. However knockout of dcuB in E. coli KRX ΔdcuB::oprF is complete and residual activity is not possible as shown in figure XXX. Comparison between E. coli wildtype and E. coli KRX ΔdcuB::oprF is an obvious demonstration of completely functional knockout of C4 carboxylate antiporter dcuB.

Fumarate reductase (Frd) from Escherichia coli
Upon the expression of fumarate reductase Frd in E. coli we analyzed the metabolic behavior under aerobic and anaerobic conditions. Successful expression of fumarate reductase Frd (BBa_1465102) could be proven via SDS-PAGE in combination with MALDI-TOF/MS. Activity of fumarate reductase displayed with HPLC analysis of fumarate consumption and succinate production in anaerobic cultivation of E. coli with BBa_1465102. Furthermore we investigated fumarate reductase activity in different E. coli strains by phenotypic MicroArray (PM) analysis with a Biolog® system.

SDS-PAGE

The fumarate reductase could be detected in purified membrane and periplasmatic protein fraction. Proteins were fractioned by cold osmotic shock of E. coli KRX at different steps after induction of protein expression. SDS-PAGE shows the expression of fumarate reductase in E. coli KRX under control of T7 promotor (BBa_1465102). Fumarate reductase with total molecular mass of 121 kD consists of four subunits. There are two large catalytic and watwer-soluble subunits, flavoprotein (66 kDa) and iron-sulfur protein (27 kDa). Two small membrane associated subunits (15 and 13 kDa) are not detectable in SDS-PAGE. (Iverson et al., 1999).
Figure XXX shows the result of SDS-PAGE of isolated membrane proteins via cold osmotic shock of E. coli KRX with BBa_1465102. There are membrane protein fractions at different times after induction of BBa_1465102 displayed.


Figure XXX: Results of SDS-PAGE of purified membrane protein from Escherichia coli BBa_1465102 via cold osmotic shock.

SDS-PAGE shows a significantly higher protein concentration in membrane extracts from E. coli expressing Frd under control of T7 promoter (BBa_1465102) after induction. This is caused by usually higher membrane protein concentration of cultivated cells. Nevertheless, a strong overexpression band can be observed at the expected Frd size (subunit A) of about 66 kDa for BBa_1465102, which can be traced back on strong expression and overproduction of Frd. Besides a overexpression band can be recognized at size about 45 kDA. This could be explained by dimer formation of two Frd subunits, for example subunit B (27 kDa) with subunit C oder D (13 and 15 kDA). That implies that subunit B build up stable dimers with small membrane associated subunits C and D of about 40 kDa respectively 42 kDa. There seems to be no dimers of subunit A with other parts of Frd.
Anaerobic cultivation

We cultivate E. coli KRX with BBa_1465102 under anaerobic conditions to characterize activity of fumarate reductase Frd (BBa_1465102) under controll of T7 promotor. We used M9 minimal medium with 50 mM xylose as carbon source and 50 mM fumarate as substrate of fumarate reductase Frd. We focused on growth characteristic and metabolite analysis. Under anaerobic conditions E. coli cells use different alternative electron acceptors instead of oxygen. In part the bacteria use fumarate respiration, whereby fumarate is reduced into succinate. There are also other potential pathways for bacteria to release their electrons, for example anorganic compounds like nitrate (NO3-) or sulfate (SO42-). As a result of this the expected level of produced succinate is very low. We analyzed fumarate and succinate concentration in culture supernatant via HPLC analysis.

We expect mid-level succinate production of E. coli KRX wildtype under anaerobic conditions. Strong expression of Frd (BBa_1465102) leads to an increasing succinate production and fumarate consumption.
As a control we use E. coli ΔfdrA730::kan, an E. coli strain with a reviewed knockout in frdA gene. This strain does not show any fumarate reductase activity and so succinate concentraion should be on a low level.
Furthermore we transform BBa_1465102 into E. coli ΔfdrA730::kan to compensate functional defect of fumarate reductase in this strain.



Figure XXX: Results of anaerobic cultivation of Escherichia coli KRX wildtype in M9 minimal medium with 50 mM xylose and 50 mM fumarate. Fumarate and succinate concentration were measured via HPLC.


Figure XXX: Results of anaerobic cultivation of Escherichia coli KRX wildtype with strong expression of frd (BBa_1465102) in M9 minimal medium with 50 mM xylose and 50 mM fumarate. Fumarate and succinate concentration were measured via HPLC.


Figure XXX: Growth of Escherichia coli KRX wildtype with strong expression of frd (BBa_1465102) compared to Escherichia coli KRX wildtype under anaerobic condition in M9 minimal medium with 50 mM xylose and 50 mM fumarate. Fumarate and succinate concentration were measured via HPLC.


Figure XXX: Comparison of fumarate consumption and succinate production in anaerobic cultivation of Escherichia coli KRX wildtype and i>Escherichia coli KRX wildtype with strong expression of frd (BBa_1465102) in M9 minimal medium with 50 mM xylose and 50 mM fumarate. Fumarate and succinate concentration were measured via HPLC.
As expected figure XXX shows production of succinate by Escherichia coli KRX wildtype under anaerobic condition with 50 mM xylose and 50 mM fumarate as sole carbon sources. Under anaerobic conditions fumarate respiration takes place. Growth displayed via OD600 shows rise in the first three days of anaerobic cultivation. After that cells were induced via 0.1% rhamnose and 500 μM IPTG. This leads to a reduction in growth because of expression load and toxic effect of IPTG. Cultivation of E. coli wildtype also should be induced because of better comparability. The same effect could be observed in cultivation of E. coli with BBa_1465102, as shown in figure XXX. There is also a drop in growth characteristic detectable. Comparison of both growth characteristics are shown in figure XXX. It could be proven that there are no distinct differences in growth betweenE. coli KRX wildtype and E. coli KRX with BBa_1465102. So statement about fumarate reductase activity in E. coli KRX with BBa_1465102 as measured by succinate production and fumarate consumption is possible.
Figure XXX shows comparison of succinate production and fumarate consumption between E. coli KRX wildtype and E. coli KRX with BBa_1465102. This illustrates an increasing succinate production by E. coli KRX with BBa_1465102 after induction of T7 promotor. A higher value of succinate could be achieved after 8 days of anaerobic cultivation and also lower fumarate level was shown compared to E. coli KRX wildtype.
Phenotypic characterization with Biolog® system

Biolog® Microbial ID System is a simple and fast method for characterization of different bactaria, yeast and fungi species. It based on respiration in the presence of different metabolic relevant substances for expample carbon sources, nitrogen sources or toxines. The system uses redox chemistry wherein a tetrazolium dye is reduced when significant respiration occurs. Tetrazolium dye change its colour, because the cells generate reductive conditions in the course of electron transport chain. Tetrazolium cation is reduced to formazan by dehydrogenase from respiratory complex I. This allow a statement if respiration occurs in the presence of different substances.

We tested the influence of fumarate on Escherichia coli KRX wildtype and E. coli KRX with BBa_1465102. To show activity of fumarate reductase under controll of T7 promotor (BBa_1465102), we incubated cells with fumarate in Biolog® system for 48h. Results of Biolog ® analysis are shown in figure XXX.

E. coli KRX wildtype and E. coli KRX with BBa_1465102 show respiratory activity in the presence of fumarate. As unexpected E. coli KRX wildtype shows higher activity on fumarate as compared to BBa_1465102. Respiration of E. coli KRX with BBa_1465102 seems to be fewer and occurs subsequently in comparison to wildtype.


Figure XXX: Results of Biolog® analysis of E.coli KRX with BBa_1465102 in comparison to Escherichia coli KRX wildtype. Respiratory activity is shown under influence of fumarate.
Figure XXX shows respiratory activity of E. coli KRX with strong expressed BBa_1465102 in comparison to E. coli KRX wildtype. As expected wildtype shows higher activity in presence of fumarate as fumarate reductase expressing strain. This effect is attributed to fumarate reductase activity.
Because Biolog® Microbial ID System based on activity in electron transport chain and reduction of tetrazolium dye, direct conclusion about fumarate consumption is not possible. But there are indirect hints for fumarate reductase activity via strong expression of BBa_1465102. Fumarate reductase naturally get electrons out of electron transport chain an trensfer them to fumarate generating succinate, which get out of the cells under anaerobic conditions. Under aerobic conditions succinate dehydrogenase oxidize succinate to fumarate again. This created loop by expression of BBa_1465102 leads to lower electron transfer activity in respiratory chain. So there are lesser electrons available for reduction of extracellular tetrazolium dye compared to E. coli KRX wildtype.
H-cell reactor

Fumarate reductase activity could be demonstrated by cultivation of E. coli KRX BBa_K1465102 in our electrobiochemical H-cell reactor. We show that expression of fumarate reductase increases electron transfer into E. coli cells via neutral red as a mediator. Results of cultivation are shown under construction results.

Fumarate reductase (Fum) from Actinobacillus succinogenes

Beside fumarate reductase (Frd) from Escherichia coli we worked on fumarate reductase (Fum) from Actinobacillus succinogenes (Fum). As published by Park et al., 1999 fumarate reductase from A. succinogenes shows high activity accepting electrical reduced neutral red a electron donor and so stimulate metabolism in a electrobiochemical reactor system. So we planed to compare these two different enzymes with regard to activity accepting neutral red or bromphenol blue as alternative electron aceptor in our electrobiochemical reactor system.

Adaptation of fum gene codon usage to E. coli KRX

The fumarate reductase Fum from A. succinogenes just as Frd from E. coli is a membrane associated enzyme, which consists of four subunits. Because there was no full genomic DNA available from A. succinogenes, we ordered Fum gene via custom gene synthesis at gBlocks® Gene Fragments. Bevor ordering DNA we ensured of optimal codon usage adapted to E. coli KRX by jcat online optimization tool. Furthermore we checked sequence for illegal restriction sites (EcoRI, PstI, NotI, XbaI) and eliminated them if required.
Because sequence is too large for synthesis in one part with gBlocks® system, we devided sequence of fum into two different parts: fumA and fumBCD (also called fumB). FumA includes coding sequence of fumarate reductase (Fum) subunit A (BBa_K1465103). However fumB consists of fumarate reductase subunits B, C and D (BBa_K1465104). FUmarate reductase ubunits get their own ribosome binding site respectively.

Cloning fumarate Reductase Fum

Two different subunits of fumarate reductase Fum from A. succinogenes has to be cloned into shipping vector pSB1C3. There occurs several problems by cloning ordered fumA and fumB into pSB1C3 via gibson assembly.
Cloning of fum was not successful a long time. Unfortunately we could not realize Ligation of fumA and fumB creating active fumarate reductase (Fum). So there are no characterizations of fumarate reductase (Fum) available. br>

Mediators

We use different mediators for electron transfer in our electrobiochemical reactor system.

Neutral Red

We tested neutral red as a mediator for electron transfer into bacterial cells. The electrochemical behavior of neutral red was analyzed in a H-cell reactor.

Bromphenol Blue

Cytochromes


Reference

Retrieved from "http://2014.igem.org/Team:Bielefeld-CeBiTec/Results/rMFC/ElectronTransfer"